• Home
  • Download PDF
  • Order CD-ROM
  • Order in Print
Section  1. LUBRICATION   INSTRUCTIONS
SYMPTOM   INDEX

TM-9-2350-238-10 Semi Trailer Tank 5000-Gallon Fuel Dispensing Automotive M969A 2 (NSN 2330-01-377-9337) Manual
Page Navigation
  129    130    131    132    133  134  135    136    137    138    139  
TM   9-2350-238-10 SERVICE     INTERVALS–UNUSUAL CONDITIONS A   lubricant   that   contains   grit, dust,  and  sand  will  be  an abrasive   and   cause   rapid   wear of   parts. Lubricate   more   frequently   to   compensate   for abnormal   or   extreme   conditions,   such   as   high or  low  temperature,  prolonged  periods  of high-speed   operation,   continued   operation   in sand   or   dust,   immersion   in   water,   or   exposure to   moisture.   Any   of   these   operations   or   condi- tions   may   quickly   destroy   protective   qualities of   lubricants.   Refer   to   FM   9-207   for   instruc- tions   on   necessary   special   preliminary   lubrica- tion  of  vehicle  for  continued  operation  below O°F    (–18°C). Intervals   may   be   extended   during   inactive periods   after   application   of   proper   lubrication. MAINTAINING   PROPER   LUBRICANT   LEVELS Lubricant   levels   in   engine,   transmission,   aux- iliary   drive,   final   drives,   road   wheel   hubs, traversing   drive,   boom   winch,   tow   winch,   and hydraulic   reservoir   must   be   observed   closely and   necessary   steps   taken   to   replenish   in order   to   maintain   proper   levels   at   all   times. LUBRICATION   AFTER   FORDING   OPERATIONS After  any  fording  operation  in  water  12  in- ches   (30.5   cm)   or   over,   lubricate   ail   chassis points   to   clean   bearings   of   water   or   grit,   as well   as   any   other   points   required,   in   accord- ance   with   page   3-61. Section  Il. TROUBLESHOOTING   PROCEDURES SECTION   INDEX Page SCOPE  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  ...3-3 TROUBLESHOOTING  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  ...3-3 Table  3-1.  Troubleshooting..  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  ...3-5 SCOPE Troubleshooting   table   3-1   lists   common malfunctions   which   may   be   found   during operation   or   maintenance   of   M578   Recovery Vehicle   or   its   components.   Perform   tests/in- spections   and   corrections   in   order   listed. TROUBLESHOOTING This  manual  cannot  list  all  malfunctions  that may   occur,   nor   all   tests   or   inspections   and corrective  actions.  If  a  malfunction  is  not listed   or   is   not   corrected   by   listed   corrective actions,   notify   unit   maintenance   personnel. SYMPTOM   INDEX Troubleshooting Procedure Page BATTERY   AND   GENERATING   SYSTEM Batteries  discharge  rapidly  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  ...3-20 Batteries  do  not  charge  when  engine  is  running  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  ...3-20 Batteries  do  not  stay  charged  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  ...3-21 No  current  in  battery  circuit  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  .  ...3-20 Change   3 3-3







Western Governors University

Privacy Statement
Press Release
Contact

© Copyright Integrated Publishing, Inc.. All Rights Reserved. Design by Strategico.